<VV> ring job - looking for running engine

[Roger Gault]

Hi, Dave,
What does, "The oil pump was stuck open and was dumping a lot of oil",
mean???
Where was the oil coming out?

A few questions come to mind.
Pull the top of the aircleaner off and see if huge amounts of smoke are
coming out of the breather pipe that runs between the aircleaner and the top
of the engine.
Pull the plugs and see if one of them is covered with oil.
Run a compression check.

Roger

----- Original Message ----- 
From: "Dave Smith" <gornzilla at gmail.com>
To: "Harry Yarnell" <hyarnell1 at earthlink.net>
Cc: <virtualvairs at corvair.org>
Sent: Friday, January 02, 2009 6:16 PM
Subject: Re: <VV> ring job - looking for running engine


> I put about 50 miles on it in LA in stop and go traffic, then drove up
> to Sacramento the next.  About 350 miles on I-5 doing 70.  I was
> keeping an eye on the gauges and a ton of smoke started coming out the
> exhaust.  I killed the key and stopped.  Stuck in Lodi again. Lost a
> quart of oil.  The oil pump was stuck open and was dumping a lot of
> oil.  I had it towed 20 miles.
>
> Some of the heads on the right side of the engine were loose, so they
> were retorqued.  There was an exhaust leak from one of them.  The
> smoke comes from the exhaust pipe.  The engine was supposed to have be
> about 2,500 miles on a rebuild.  The mechanic said it might've been
> rebuilt and there wasn't any sounds from the bottom end.
>
> I like my NSU being a project car, not the Corvair.
>
> -Dave
>
>
> On Fri, Jan 2, 2009 at 2:17 PM, Harry  Yarnell <hyarnell1 at earthlink.net>
wrote:
> > I assume the smoke is coming out the exhaust pipe, not from under or out
of
> > the engine bay. Makes a big difference.
> >
> > Harry Yarnell
> > Perryman garage and orphanage
> > Perryman, MD
> > hyarnell1 at earthlink.net
> > ----- Original Message ----- From: "Dave Smith" <gornzilla at gmail.com>
> > To: <virtualvairs at corvair.org>
> > Sent: Friday, January 02, 2009 4:28 PM
> > Subject: Re: <VV> ring job - looking for running engine
> >
> >
> >> Thanks, all.  I plan on showing up at the local meeting and I joined
> >> CORSA.
> >>
> >> The description of the car is what got me to buy it.  I figured
> >> correctly it wouldn't sell for much since it's a Texas car and the
> >> body is a bit rough.  Plus December is a bad time to sell a vehicle.
> >>
> >> It started right up and didn't smoke until 20 miles from home. I had
> >> it towed after it died.  I put about 350 miles on it.  I can try some
> >> Marvel Mystery Oil but it's undriveable as it is.  Way more than any
> >> 2-stroke motorcycles or scooter I've seen.
> >>
> >> -Dave
> >>
> >>
> >
>  _______________________________________________
> This message was sent by the VirtualVairs mailing list, all copyrights are
the property
> of the writer, please attribute properly. For help,
mailto:vv-help at corvair.org
> This list sponsored by the Corvair Society of America,
http://www.corvair.org/
> Post messages to: VirtualVairs at corvair.org
> Change your options:
http://www.vv.corvair.org/mailman/options/virtualvairs
>  _______________________________________________