<VV> Bucking / Stalling diagnostics

[Doug Mackintosh]

OK all you diagnostics wizards, I need help!
 
My daughter's Spyder has an intermittant bucking / stalling problem. This has been going on, but progressively getting worse, over the last few months. In addition to the bucking / stalling it had difficulty revving over 4000 RPM and the tach needle would wiggle and drop when it was bucking. I found a very sloppy distributor bushing and repaired that, which seems to have cured those problems. The car ran like a champ after that for 2-3 days.
 
But last night we went for a Corvair cruise out on the back roads and after about 30 minutes of spirited driving it started acting up. Here are the symptoms:
 
- It starts and drives fine for a while
- It then starts to buck (jerk) intermittantly
- The bucking increases in frequency and severity
- It then stalls for a few seconds, then catches again and is OK
- The stalling recurs, increasing in frequency and lasting longer each time
- Eventually it stalls long enough that the car coasts to a stop. After waiting a minute, it can be restarted and goes a short distance before it happens again
- Last night, we stalled at a convenient place and I let it sit a few minutes, then had Leigh crank it while I checked for spark (coil wire held near ground) - nice fat spark (but it may have already cured itself from the resting time). We restarted and drove (at a leisurely pace) about 10 minutes back home.
 
>From the behavior I have seen I am suspicious that the problem is heat related since it never stalls until we have been on the road awhile, and it seems to cure itself by sitting briefly, and it seems the longer it sits, the longer it stays "fixed". Also it seems to get progressively worse and more frequent with driving time. The only other possibility I can think of is a partially plugged gas cap vent making it "run out of gas".
 
I eagerly await your suggestions! When we get to the bottom of it, I will post the results.
 
Thanks! 
 

-- Doug Mackintosh
Corsa member since 1996
Corsa/NC member since 1996, Virtual Vairs member
Corvair owner 1969-1971 and 1996-on


      __________________________________________________________
Not happy with your email address?.
Get the one you really want - millions of new email addresses available now at Yahoo! http://uk.docs.yahoo.com/ymail/new.html