<VV> Time to Fix the Vapor Lock

[Louis C. Armer, Jr.]

Sender unit has collasped inlet sock or clogged with trash,gum,varnish
and rust. Gas trickles through when the motor is off and fills carbs. You
run the engine the vaccum collapses the impeded sock and fuel starvation
occurs.

The vent on your gas tank is closed due to trash,dirt or rust. Try running 
with
new cap or with cap off.

Cheers,
Chuckster

//////////////////////////////////////////////////////////////////////



At 09:31 AM 4/21/04 -0400, you wrote:
>VVers:
>
>I wrote some time ago about a vapor lock problem my Monza had been
>experiencing.  I just took it out for the season this past weekend and
>noted that the problem has gotten worse.  I'm going to try and tackle it
>once and for all this weekend.
>
>The facts:
>
>     Car -- 65 Monza, 110/4spd.
>
>     Symptoms -- I drive the car for a while and shut the engine off
>     (e.g., to run into the grocery store). When I start it up, it
>     travels about a 1/4-1/2 mile and stalls.  In other words, just long
>     enough to go down the road and use up the fuel in the carb bowls.
>
>     Temporary Cure -- Waiting 30-45 minutes for a cool down allows it to
>     start back up, but only after some considerable cranking.
>     Presumably, this allows to fill the carbs back up.
>
>I went through some old emails on the subject, and have compiled
>everyone's recommendations/opinions.  These are:
>
>     * Could be a pinhole leak in the gas line between the tank and pump
>     * Rubber hose could be expanding and allowing air to get sucked into
>       the fuel line.
>     * A fuel pump can and will cause just that problem.
>     * If you have another "known good" fuel pump around, try swapping it.
>     * Could be a loose valve (unstaked) in the fuel pump.
>
>With this much information, it seems to me that I should try to fix this
>problem by replacing:
>
>     * The rubber hose between the tank and the steel line in the tunnel
>     * The rubber hose between the steel line and the engine
>     * The fuel pump
>
>Anything else I should look into?
>
>On a related note, does anyone have some advice on the best place to go
>for a reliable (mechanical) fuel pump?  Have all the bad ones been
>cleaned out of the vendors' inventories?
>
>Thanks.
>
>Steven "tired of waiting and cranking" Serenska
>_______________________________________________
>This message was sent by the VirtualVairs mailing list, all copyrights are 
>the property
>of the writer, please attribute properly. For help, mailto:vv-help@corvair.org
>This list sponsored by the Corvair Society of America, http://www.corvair.org/
>Post messages to: VirtualVairs@corvair.org
>List info: http://www.vv.corvair.org/mailman/listinfo/virtualvairs


Corvair Atlanta, BOD
CORSA MEMBER
CORSA Tri-Membership Chairman
http://carmerjr.home.mindspring.com/